按作业方式分类
Classification by operation mode
⑴按作业方式分有循环作业式和连续作业式两种。
⑴ According to the operation mode, there are two types: circular operation type and continuous operation type.
循环作业式的供料、搅拌、卸料三道工序是按一定的时间间隔周期进行的，即按份拌制。
The three processes of feeding, mixing and unloading of circulating operation are carried out at a certain time interval, that is, batch mixing.
由于拌制的各种物料都经过准确的称量，故搅拌质量好。大多采用此种类型的作业方式。
The mixing quality is good because all materials are accurately weighed. This type of operation is mostly adopted.
连续作业式的上述三道工序是在一个较长的筒体内连续进行的。虽然其生产率较循环作业式高，但由于各料的配合比、搅拌时间难以控制，故搅拌质量差。使用较少。
The above three processes of continuous operation are carried out continuously in a long cylinder. Although its productivity is higher than that of circular operation, the mixing quality is poor because the mix proportion and mixing time of each material are difficult to control. Less used.
按搅拌方式分类
Classified by mixing method
⑵按搅拌方式分有自落式搅拌、强制式搅拌两种。
⑵ According to the mixing method, there are two types of mixing: self dropping mixing and forced mixing.
自落式搅拌机就是把混合料放在一个旋转的搅拌鼓内，随着搅拌鼓的旋转，鼓内的叶片把混合料提升到一定的高度，然后靠自重自由撒落下来。这样周而复始地进行，3方自上料搅拌车，直拌匀为止。这种搅拌机一般拌制塑性和半塑性混凝土。
The self dropping mixer is to place the mixture in a rotating mixing drum. With the rotation of the mixing drum, the blades in the drum lift the mixture to a certain height, and then it can be freely scattered by its own weight. In this way, it will be carried out repeatedly. How much will it cost from the charging mixer truck until it is well mixed. This mixer generally mixes plastic and semi plastic concrete.
强制式搅拌机是搅拌鼓不动，而由鼓内旋转轴上均置的叶片强制搅拌。这种搅拌机拌制质量好，生产效率高；但动力消耗大，且叶片磨损快。一般适用于拌制干硬性混凝土。
Compulsory mixer is the mixing drum is not moving, but is forced to mix by uniformly placed blades on the rotating shaft inside the drum. The mixer has good mixing quality and high production efficiency; However, the power consumption is high and the blades wear quickly. It is generally applicable to mixing dry and hard concrete.
按装置方式分类
Classification according to device mode
⑶按装置方式分有固定式和移动式两种。
⑶ There are two types of devices: fixed type and mobile type.
固定式搅拌机是安装在预先准备好的基础上，整机不能移动。它的体积大，生产效率高。多用于搅拌楼或搅拌站。
The fixed mixer is installed on the prepared foundation, and the whole machine cannot be moved. It has large volume and high production efficiency. It is mainly used in mixing plants or mixing plants.
移动式搅拌机本身有行驶车轮，且体积小，重量轻，故机动性能好。应用于中小型临时工程。
The mobile mixer itself has driving wheels, and is small in size and light in weight, so it has good mobility. It is applied to small and medium-sized temporary works.

按出料方式分类
Classified by discharging method
⑷出料方式分有为倾翻式和非倾翻式两种。
⑷ There are two kinds of discharging methods: tipping type and non tipping type.
倾翻式靠搅拌鼓倾翻卸料，而非倾翻式靠搅拌鼓反转卸料。
The tipping type relies on the tipping of the mixing drum for unloading, rather than the tipping type relies on the reversing of the mixing drum for unloading.
形状分类
Shape classification
⑸按搅拌鼓的形状不同，有梨型、鼓筒型、双锥形、圆盘立轴式和圆槽卧轴式五种。前三种系自落式搅拌；后两种为强制式搅拌，国内较少使用。
(5) According to the different shapes of mixing drums, there are five types: pear type, drum type, biconical type, disc vertical shaft type and circular groove horizontal shaft type. The first three are self dropping stirring; The latter two are forced mixing, which is seldom used in China.
1、自上料搅拌车定时替换机油及滤芯，任何质量等级的润滑油在运用过程中油质都会发作变化，为了防止毛病的发作，运用条件定时换油，并使油量适中（通常以机油标尺上限为好）。
1. The engine oil and filter element shall be replaced regularly from the feeding mixer, and the oil quality of lubricating oil of any quality level will change during operation. In order to prevent the occurrence of faults, the oil shall be replaced regularly under the operating conditions, and the oil quantity shall be moderate (usually the upper limit of the engine oil scale is better).
2、自上料搅拌车运用恰当质量等级的润滑油，对汽1油发动机应依据进排气体系的附加设备和运用条件选用SD-SF级汽1油机油；柴油发动机则要依据机械负荷选用CB-CD级柴油机油，自上料搅拌车，选用规范以不低于生产厂家规则请求为准。
2. The lubricating oil of appropriate quality grade shall be used for the self feeding mixer, and SD-SF grade gasoline engine oil shall be selected for gasoline engine according to the additional equipment and operating conditions of the intake and exhaust system; For diesel engine, CB-CD diesel engine oil shall be selected according to the mechanical load, and the price of self feeding mixer truck shall not be lower than the manufacturer's rules.
3、搅拌车定时清洁燃油体系，操控积炭的生成，可以使发动机保持较好状态。
3. The mixer can clean the fuel system regularly and control the generation of carbon deposits to keep the engine in good condition.
4、搅拌车养护三滤：三滤是指空气滤清器、机油滤清器及汽1油滤清器，自上料搅拌车，如今大多数汽1油机都装有PCV阀（曲轴箱强行通风设备），但窜气中的污染物会沉积在PCV阀的周围，可能使阀阻塞。因而，须定时铲除PCV阀周围的污染物。
4. Maintenance of mixer truck with three filters: three filters refer to air filter, oil filter and steam oil filter. Since the mixer truck is loaded, most steam oil engines are now equipped with PCV valves (forced crankcase ventilation), but pollutants in the blowby will deposit around the PCV valves, which may block the valves. Therefore, the pollutants around the PCV valve must be removed regularly.
自上料搅拌车主要用于混凝土工程，主要用于混凝土搅拌，也称为混凝土搅拌车。商品混凝土搅拌车采用流行的快速组装模块类型结构、高性能进口搅拌器，自上料搅拌车厂家，双机双控制的计算机控制方式，防止噪音，防止粉尘污染，环境设计，是新一代的水泥混凝土搅拌设备，适用于城市商品预拌混凝土、道路和桥梁、水利、机场、港口和其他大型基础设施建设项目具体需求。
The self loading mixer is mainly used for concrete works and concrete mixing, also known as concrete mixer. The commercial concrete mixer adopts the popular quick assembly module type structure, high-performance imported mixer, self loading mixer manufacturer, double machine and double control computer control mode to prevent noise and dust pollution. The environmental design is a new generation of cement concrete mixing equipment, which is suitable for the specific needs of urban commercial ready mixed concrete, roads and bridges, water conservancy, airports, ports and other large-scale infrastructure construction projects.
混合站的防护:
Safety protection of mixing station:
工作在安装过程中，严禁倾斜、腿部变形等。
During installation, it is strictly forbidden to tilt or deform the legs.
支撑腿的底部和基部预埋件焊接牢固。
The embedded parts at the bottom and base of the support leg shall be welded firmly.
良好的防风防雷工作。
Good wind and lightning protection.
对腿部和筒仓有强烈的冲击。
It has a strong impact on legs and silos.
定期检查收尘器的水泥粘连，清洗袋中。
Regularly check the cement adhesion of the dust collector and clean the bag.
基础必须牢固，符合建筑设计规范。
The foundation must be firm and conform to the building design specifications.
以上就是为大家介绍的有全自动自上料搅拌车的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.jufengjiaobanji.com
The above is a detailed introduction of the fully automatic self feeding mixer, which I hope will be helpful to you. If you have any questions, please contact us. We will provide you with professional services http://www.jufengjiaobanji.com/