Self loading concrete mixer truck is a machine that mixes cement, sand, gravel, aggregate and water and mixes them into concrete mixture. It is mainly composed of a mixing drum, a water supply / unloading mechanism, a water supply system, a prime mover, a transmission mechanism, a frame and a support device. Only when the equipment is operated safely and reasonably can the operation performance of the equipment be improved. Therefore, the following editor will introduce the safe operation rules of the equipment.

1.驾驶之前，请仔细检查车辆的状况，以确保可以安 全行驶。

1. Before driving, please carefully check the condition of the vehicle to ensure safe driving.

2.如果将自动上料搅拌车停在室外，则在装载前需要颠倒搅拌桶以排出水和碎屑，以确保混凝土的质量。

2. If the automatic loading mixer is parked outdoors, the mixing drum needs to be reversed before loading to discharge water and debris to ensure the quality of concrete.

3.骗局运输防滑钉时，请牢固放置倾斜的槽，以免因松动而晃动，伤害行人或影响其他行驶中的车辆的正常运行，同时防止混凝土溢出和污染。地面。

3. When transporting anti-skid nails by scam, please firmly place the inclined groove to avoid shaking due to looseness, hurting pedestrians or affecting the normal operation of other moving vehicles, and prevent concrete overflow and pollution. Ground.

4.自动上料搅拌车运输混凝土所需的时间不得超过搅拌站规定的时间。在混凝土运输过程中，请勿长时间停止搅拌桶，以防止混凝土偏析。驾驶员应不时观察具体情况，向主控室报告异常情况，并提出处理要求。

4. The time required for the automatic loading mixer to transport concrete shall not exceed the time specified in the mixing plant. During concrete transportation, do not stop the mixing bucket for a long time to prevent concrete segregation. The driver shall observe the specific situation from time to time, report the abnormal situation to the main control room and put forward handling requirements.

5.如果车辆装有混凝土，则现场停滞时间不应超过一小时。如果超时，现场人员将需要及时处理。

5. If the vehicle is equipped with concrete, the on-site dead time shall not exceed one hour. In case of overtime, the on-site personnel will need to deal with it in time.

6.当用混凝土搅拌机运输未泵送的物料时，如果混凝土进入罐中到排出之间的温度高，则不应超过2小时，并且必 须在2小时后排出。雨中温度较低时，不应超过2.5小时。

6. When transporting non pumped materials with a concrete mixer, if the temperature between the concrete entering the tank and discharging is high, it shall not exceed 2 hours and must be discharged after 2 hours. When the temperature in the rain is low, it shall not exceed 2.5 hours.

7.沥干混凝土之前，以10-12rpm的速度旋转搅拌桶1分钟，然后沥干。

7. Before draining the concrete, rotate the mixing drum at the speed of 10-12 rpm for 1 minute, and then drain.

8.自上料混凝土搅拌罐车卸完后，立即使用连接到车辆的软管冲洗入口，卸料斗和卸料斜槽，以清除车身上的污垢和残留的混凝土，并保持车辆的卫生。

8. Immediately after the unloading of the loading concrete mixing tank truck, flush the inlet, unloading hopper and unloading chute with the hose connected to the vehicle to remove the dirt and residual concrete on the vehicle body and maintain the sanitation of the vehicle.

以上就是小编为大家介绍的相关内容，希望可以帮助到您，更多精彩内容可以直接关注http://www.jufengjiaobanji.com或者搜索：自上料混凝土搅拌罐车厂家都可以找到我们。

The above is the relevant content introduced by Xiaobian. I hope it can help you. More wonderful content can be directly concerned http://www.jufengjiaobanji.com Or search: we can be found by the manufacturer of concrete mixing tank truck since loading.